EFFECT OF STYRENE BUTADIENE RUBBER LATEX ON MECHANICAL PROPERTIES OF ECO CONCRETE: LIMESTONE POWDER CONCRETE

Al Numan, Bayan S.; Ahmed, Faris R.; Hamad, Kamaran K.

doi:10.14500/aro.10212

	EFFECT OF STYRENE BUTADIENE RUBBER LATEX ON MECHANICAL PROPERTIES OF ECO CONCRETE: LIMESTONE POWDER CONCRETE
ARO-THE SCIENTIFIC JOURNAL OF KOYA UNIVERSITY
Article 1, Volume 6, Issue 1, 2018, Pages 1-6 PDF (1.54 M)
DOI: 10.14500/aro.10212
Authors
Bayan S. Al Numan; Faris R. Ahmed; Kamaran K. Hamad
Abstract
To make concrete a truly green material, viable cement substitutes are available. This experimental investigation is performed to study the effect of using limestone powder (LSP) and styrene butadiene rubber (SBR) latex in the concrete mix. In this work, a concrete with 1:1.8:3 cementitious material:sand:gravel and water/cement ratio w/c of 0.5 is produced. First, LSP is used with 0, 5, 10, 15, and 20% replacements by weight of cements. The fineness of the LSP is measured using sieve No. 200 and showed about 30% pass. Second, and to improve the matrix of concrete due to the dilution effect, four ratios of SBR latex (0, 5, 10, and 15%) are added by weight of cements to the mix for each LSP ratio. Compressive strength at ages of 3, 7, 14, 28, and 90 days is tested for the concrete specimens mixed with LSP only to examine its effect on concrete strength’s development with time, whereas strengths are recorded at the age of 28 days for the other concretes. Three prisms were cast for each ratio and tested at 28 days. The results show general improvements in terms of compressive and flexural strengths.
Keywords
compressive strength; flexural strength; Limestone filler; Portland cement; Styrene butadiene rubber latex

References
Abd Elkam, A.A., Abd Elmoaty, A.E., 2012. Experimental investigation on the properties of polymer modified SCC, Jr. Construction and Building Materials, 34, pp.584-592. Ahmed, A., Abdurrahman, A. and Mohammed, Z., 2009 Influence of limestone powder as partial replacement of cement on concrete and the effect of high temperature on it, IASJ. Al-Rafidain Engineering Journal, 18(5), pp.24-34. ASTM C1042-99, 1999. Standard Test Method for Bond Strength of Latex Systems used with Concrete by Slant Shear (Withdrawn 2008). ASTM International, West Conshohocken. ASTM C1059/C1059M-99, 1999. Standard Specification for Latex Agents for Bonding Fresh To Hardened Concrete. ASTM International, West Conshohocken. ASTM C150/C150M-02, 2002. Standard Specification for Portland Cement. ASTM International, West Conshohocken. Essa, M., Abdul-Amir, A. and Hassan, N., 2012. Effect of ading (SBR) on concrete properties and bond between old and new concrete. Kufa Journal of Engineering, 4(1), pp.81-95. Noori, Z., 2016. Compaction and shear behaviour of low plasticity clayey soils treated by crushed lime. International Journal of Engineering Technology, Management and Applied Sciences, 4(6), pp.193-199. Obla, K. H., “What is Green Concrete,” Concrete InFocus, V. 8, No. 2, Spring 2009. Available from: https://www.nrmca.org/research_engineering/Documents/ What_is_Green_Concrete.pdf. [Last accessed on 2016 Sep 26]. Tarun, R., Canpolat, F. and Chun, Y., 2003. Limestone Powder Use in Cement and Concrete, Report No. CBU-2003-31, REP-525. Available from: http:// www4.uwm.edu/cbu/Papers/2003%20CBU%20Reports/REP-525.pdf. [Last accessed on 2016 Nov 10]. Thongsanitgarn, P., Wongkeo, W., Sinthupinyo, S. and Chaipanich, A., 2011. Effect of Limestone Powders on Compressive Strength and Setting Time of Portland-Limestone Cement Pastes. Tiche International Conference 2011, November 10-11, At Hatyai, Songkhla Thailand. Wang, R., Wang, M. and Li, X.G., 2005. Physical and mechanical properties of styrene-butadiene rubber emulsion modified cement mortars. Journal Cement and Concrete Research, 35, pp.900-906. Yao, S. and Ge, Y., 2012. Effect of styrene butadiene rubber latex on mortar and concrete properties. Advanced Engineering Forum, 5, pp.283-288.
Statistics Article View: 27 PDF Download: 36