| This paper presents an experimental investigation of thermal insulation in rubberized concrete blocks, where the fine aggregate size was replaced by rubber crumbs at varying ratios (0%, 10%, 20%, 30%, 40%, and 50%). The rubber crumbs used in this study ranged in size from 0-1mm, 1-3mm, and 2-4mm. A mixing ratio of 4:2:1 was employed, and simulated solar energy at a rate of 500 W/m2 was applied to the outer surface of the test samples. Heat flux sensors were installed on both the internal and external surfaces to measure transient heat flux through the samples, while K-type sensors were used to measure surface temperatures. The samples were placed in an adiabatic room with an open front side for testing. The results of the study indicate that the addition of rubber crumbs to the concrete mixture improves thermal insulation properties, as evidenced by a decrease in thermal conductivity corresponding to the volumetric substitution ratio of rubber crumbs with the volume of sand in the sample. Particularly, a 50% incorporation of rubber crumbs led to a substantial 76.2% reduction in thermal conductivity, indicating the effective thermal insulation provided by rubberized concrete. These findings hold significant implications for energy conservation within the building sector, where the use of rubberized concrete can contribute to improved energy efficiency and reduced heat transfer. |
- Ministry of Electricity, Annual statistical report for the year 2019, Iraq. More Information in: https://moelc.gov.iq
- Ghandi A, Sergey P. Global CO2 impacts of light-duty electric vehicles. Transportation Research Part D: Transport and Environment 2020; 87: 102524. https://doi.org/10.1016/j.trd.2020.102524
- Iraqi Central Statistical Organization Yearly Statistics, Ministry of Planning Baghdad. 2020. Information on: center –statistical. https://mop.gov.iq
- Sukontasukkul P. Use of crumb rubber to improve thermal and sound properties of pre-cast concrete panel. Construction and Building Materials 2009; 23 (2):1084-1092. https://doi.org/10.1016/j.conbuildmat.2008.05.021.
- Kashani, A, Tuan DN, Priyan M , Jay RB, Ailar H . A sustainable application of recycled tire crumbs as an insulator in lightweight cellular concrete. Journal of cleaner production 2017; 149:925-935. https://doi.org/10.1016/j.jclepro.2017.02.154.
- Hall MR, Khalid B N, Christina J. H. Transient thermal behaviour of crumb rubber-modified concrete and implications for thermal response and energy efficiency in buildings. Applied thermal engineering 2012; 33:77-85. https://doi.org/10.1016/j.applthermaleng.2011.09.015
- Yesilata B, Husamettin B, Paki T. Experimental study on the thermal behavior of a building structure using rubberized exterior walls. Energy and Buildings 2011; 43(2-3): 393-399. https://doi.org/10.1016/j.enbuild.2010.09.031
- Alaa, L H, Hyder H B, Khaled A A F. Experimental Investigation of the Thermal Performance of Scrap Tire Rubber-Concrete Blocks. Key Engineering Materials. Trans Tech Publications Ltd 2022; 911: 139-144. https://doi.org/10.4028/p-3on415.
- Alaa L H, Husam J F. Experimental assessment for the thermal performance of scrap tire blocks as external wall insulators. Engineering Reports 2022; 4(12): e12542. https://doi.org/10.1002/eng2.12542
- Husam J F, Alaa L H. The effect of using scrap tire powder in the perforated brick holes on thermal insulation. Al-Qadisiyah Journal for Engineering Sciences 2021; 14(2): 074-080. https://doi.org/10.30772/qjes.v14i2.749
- Fraile G E, Ferreiro C J, Mendivil G M, San Vicente N A. Thermal behavior of hollow blocks and bricks made of concrete doped with waste tire rubber. Construction and building materials 2018; 176, 193-200. https://doi.org/10.1016/j.conbuildmat.2018.05.015
- ASTM Standard D6814, 2002 (2013) Standard test method for determination of percent devulcanization of crumb rubber based on crosslink density ASTM International, West Conshohocken, PA, 2006, DOI: 10.1520/D6814-02R13.2, astm.org.
- Central Organization for Standardization and Quality Control, Iraqi Standards, Portland Cement, Code No. 5, 1984.
- Central Organization for Standardization and Quality Control, Iraqi Standards, Rubble of natural resources used in concrete and construction, Code No. 45, 1984.
- https://applent.en.made-inchina.com/product/oNpQCiPlYJkU/China-At4516-16-Channels-Temperature-Data-Logger-for-LED-Industry.html.
- More information in: https://www.fluxteq.com/.
- Central Organization for Standardization and Quality Control, Iraqi Standards, Rubble of natural resources used in concrete and construction /Code of thermal insulation /Iraqi blog, Code No.501, 2013.
- Ashraf F, Fouad A, Taher A L, Ellie F. Use of crumb rubber to improve the thermal efficiency of cement-based materials. American Journal of Engineering and Applied Sciences 2014; 7(1), 1-11, https://doi.org/10.3844/ajeassp.2014.1.11.
- Benazzouk A, Douzane O, Mezreb K, Laidoudi B, Quéneudec M. Thermal conductivity of cement composites containing rubber waste particles: Experimental study and modeling. Construction and Building Materials 2008; 22.4: 573-579. https://doi.org/10.1016/j.conbuildmat.2006.11.011.
- Muhammad, S. K., Eqqab Maree, I., Ibraheem, R. R. (2022). 'Influence of intake air temperature on the performance of gasoline engines using a different type of fuel', Al-Qadisiyah Journal for Engineering Sciences, 15(4), pp. 229-237. doi: 10.30772/qjes.v15i4.806
|
